全自動水泥撒布車在道路工程建設中發揮著重要的作用，和以往的人力施工相比更環保、更高效、更節能，所以得到廣泛應用。眾所周知，對車輛進行定期維護保養有利于延長設備的使用壽命，那么水泥撒布車的維護保養要點您了解多少呢？

　　The fully automatic cement spreading vehicle plays an important role in road engineering construction. Compared with traditional manual construction, it is more environmentally friendly, efficient, and energy-saving, so it has been widely used. As is well known, regular maintenance of vehicles is beneficial for extending the service life of equipment. So, how much do you know about the maintenance points of cement spreading vehicles?

　　下面，小編為大家整理了一些水泥撒布車的維護保養小知識，一起來了解相關內容吧。

　　Below, the editor has compiled some maintenance tips for cement spreading trucks. Let's learn about the relevant content together.

　　空濾的作用

　　The function of air filtration

　　在車輛的千千萬萬個零部件中，空氣濾清器是一個極不起眼的部件，因?yàn)樗恢苯雨P(guān)系到汽車的技術性能，但在車輛的實際使用中，空氣濾清器卻對車輛（特別是發動機）的使用壽命有極大的影響。一方面，如果沒有空氣濾清器的過濾作用，發動機會吸入大量含有塵埃、顆粒的空氣，導致發動機氣缸磨損嚴重；另一方面，如果在使用過程中，長時間不進行維護保養，空氣濾清器的濾芯就會沾滿空氣中的灰塵，這不但使過濾能力下降，而且還會妨礙空氣的流通，導致混合氣過濃而使發動機工作不正常。因此，按期維護保養空氣濾清器是至關重要的。

　　Among the countless components of a vehicle, the air filter is a very inconspicuous part because it is not directly related to the technical performance of the car. However, in actual use of the vehicle, the air filter has a great impact on the service life of the vehicle (especially the engine). On the one hand, without the filtering effect of an air filter, the engine will inhale a large amount of air containing dust and particles, resulting in severe cylinder wear; On the other hand, if maintenance is not carried out for a long time during use, the filter element of the air filter will be covered with dust in the air, which not only reduces the filtering ability, but also hinders the circulation of air, resulting in excessive mixture and abnormal engine operation. Therefore, regular maintenance of the air filter is crucial.

　　干過濾式濾清的保養：干過式空氣濾清裝置由紙質濾芯及密封墊圈等組成，使用中應注意

　　Maintenance of dry filtration: The dry filtration air filtration device consists of a paper filter element and a sealing gasket. Attention should be paid during use

　　1、定期檢查，正確保潔。清除紙濾芯上的灰塵時，應用軟毛刷沿時，應用軟毛刷沿折縫方向刷去濾芯表面灰塵土，并輕輕敲擊端面使塵土脫落。進行上述操作時，應用干凈的棉布或橡皮塞堵住濾芯兩端，以壓縮空氣機或打氣筒（氣壓不得超過 0.2-0.3MPA，以防損壞濾紙）從濾芯內向外吹氣，以吹去粘附在濾芯外表面上的灰塵。

　　1. Regular inspections and proper cleaning. When removing dust from the paper filter element, use a soft bristled brush to brush away the dust and dirt on the surface of the filter element along the crease direction, and gently tap the end face to remove the dust. When performing the above operation, use a clean cotton cloth or rubber stopper to block both ends of the filter element, and use a compressed air machine or an air pump (with a pressure not exceeding 0.2-0.3MPA to prevent damage to the filter paper) to blow air from inside the filter element to the outside to remove dust adhering to the outer surface of the filter element.

　　2、不要用水或柴油、汽油清洗紙質濾芯，否則濾芯孔隙被堵塞，增加空氣阻；同時柴油易吸入氣缸，造成裝后超支“飛車”。

　　2. Do not clean the paper filter element with water, diesel, or gasoline, otherwise the pores of the filter element will be blocked, increasing air resistance; At the same time, diesel is easily drawn into the cylinder, causing overspending and "flying" after installation.

　　3、當發現濾芯破損，或?yàn)V芯上、下端面翹不平，或橡膠密封圈老化變形、破損，均應更換新件。

　　3. When the filter element is found to be damaged, or the upper and lower ends of the filter element are uneven, or the rubber sealing ring is aged, deformed, or damaged, new parts should be replaced.

　　4、安裝時，要注意各結合部件的墊片或密封圈不得漏裝或錯裝，以免空氣短路。濾芯蝶形螺母不要擰得過緊，以防壓壞濾芯。

　　4. During installation, it is important to ensure that the gaskets or sealing rings of each joint component are not missing or incorrectly installed to prevent air short circuits. Do not tighten the butterfly nut of the filter element too tightly to prevent damage to the filter element.

　　副發動機空濾

　　Secondary engine air filter

　　底盤空濾

　　Chassis air filter

　　通過我們的一番介紹，相信大家對水泥撒布車的維護保養要點有了相應的了解，只有按照正確的維護保養方法，才能延長機器的使用壽命，提高設備的工作效率。

　　Through our introduction, we believe that everyone has gained a corresponding understanding of the maintenance points of cement spreader trucks. Only by following the correct maintenance methods can the service life of the machine be extended and the work efficiency of the equipment be improved.

　　本文由  水泥撒布車出租  友情奉獻.更多有關的知識請點擊  http://m.622410.cn/   真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

　　This article is a friendly contribution from a cement spreader rental For more related knowledge, please click http://m.622410.cn/ Sincere attitude To provide you with comprehensive services We will gradually contribute more relevant knowledge to everyone Coming soon.