智能撒布車的施工預防措施和維護要求！_公司新聞

公司新聞

智能撒布車的施工預防措施和維護要求！

來源：http://m.622410.cn/ 日期：2021-02-26

　　智能水泥撒布車是公路維護和修理中必不可少的工具，隨著公路建設的不斷發展，對智能撒布車的需求也在增加。

　　Intelligent cement spreader is an indispensable tool in highway maintenance and repair. With the continuous development of highway construction, the demand for intelligent spreader is also increasing.

　　使用智能噴頭時，應注意以下幾點：

　　When using intelligent sprinkler head, the following points should be paid attention to:

　　1.在操作前，應檢查轎廂的各個部分，管道系統的閥門，噴嘴和其他工作裝置，它們可以正常使用而不會出現故障。

　　1. Before operation, check all parts of the car, valves, nozzles and other working devices of the pipeline system, which can be used normally without failure.

　　2.在檢查同步密封小車無故障后，將小車駛?cè)爰佑凸芟路?，首先將所有閥門置于關閉位置，打開油箱頂部的小油箱蓋，將加油管放入，然后啟動加注瀝青并加油完成后，關閉小加油口蓋，填充的瀝青要滿足溫度要求，并且不能填充得太滿。

　　2. After checking that the synchronous sealing car is free of fault, drive the car under the oil filling pipe. First, put all the valves in the closed position, open the small oil tank cover on the top of the oil tank, put the oil filling pipe in, and then start filling asphalt and fill the oil. After the completion of filling, close the small filler cap. The filled asphalt should meet the temperature requirements and not be filled too full.

　　3.在智能撒布車中裝滿瀝青和碎石后，它會緩慢啟動，并保持中速行駛到施工現場。

　　3. After the intelligent spreader is filled with asphalt and gravel, it will start slowly and drive to the construction site at medium speed.
水泥撒布車租賃

　　4.運至施工現場后，如果同步密封車罐體中的瀝青溫度不能滿足噴涂要求，則必須加熱瀝青，在瀝青加熱過程中，可以打開瀝青泵以實現均勻的溫度上升，我公司生產的同步礫石密封取力器可以在行駛過程中關閉并加熱。

　　4. After being transported to the construction site, if the asphalt temperature in the tank of the synchronous sealing vehicle can not meet the spraying requirements, the asphalt must be heated. During the asphalt heating process, the asphalt pump can be turned on to realize uniform temperature rise. The synchronous gravel sealing power take-off produced by our company can be closed and heated during driving.

　　5.罐中的瀝青達到噴涂要求后，將同步密封車駛至后噴嘴，從操作起點開始在約1.5-2m處停止，根據施工要求，可以選擇在前臺控制自動噴涂，在后臺控制手動噴涂，在運行過程中，禁止站在中間平臺上，必須保持勻速行駛，禁止踩油門。

　　5. After the asphalt in the tank meets the spraying requirements, drive the synchronous sealing vehicle to the rear nozzle and stop at about 1.5-2m from the starting point of operation. According to the construction requirements, automatic spraying can be controlled at the front desk, and manual spraying can be controlled in the background. During the operation, it is forbidden to stand on the intermediate platform, and driving at a constant speed must be maintained, and it is forbidden to step on the accelerator.

　　6.當操作完成或施工現場改變一半時，必須清洗過濾器，瀝青泵，管道和噴嘴。

　　6. When the operation is completed or half of the construction site is changed, the filter, asphalt pump, pipeline and nozzle must be cleaned.

　　7.每天使用智能噴頭后，您必須清潔同步車，以使智能噴頭能夠長期為我們工作。

　　7. After using the intelligent sprinkler every day, you must clean the synchronous car, so that the intelligent sprinkler can work for us for a long time.

　　以上是關于對智能撒布車的施工預防措施和維護要求的介紹，相信大家都有所了解了，如想了解更多內容歡迎點擊水泥撒布車租賃網站。

　　The above is about the construction of intelligent spreader preventive measures and maintenance requirements, I believe you all know, if you want to know more, welcome to click the cement spreader rental website.

上一條：使用冷再生機路面平整工作是如何進行的？

下一條：簡述泡沫瀝青冷再生技術的質量檢測程序！